S.I. No. 406/2006 - European Communities (Carriage of Dangerous Goods by Road) (ADR Miscellaneous Provisions) Regulations 2006

REGULATIONS

entitled

European Communities (Carriage of Dangerous Goods by Road) (ADR Miscellaneous Provisions) Regulations 2006.

S.I. No. 406 of 2006

I, Micheál Martin, Minister for Enterprise, Trade and Employment, in exercise of the powers conferred on me by Section 3 of the European Communities Act 1972 (No. 27 of 1972) as amended by Section 5 of the European Communities (Amendment) Act 1993 (No. 25 of 1993), and for the purpose of giving further effect to Council Directive 94/55/EC of 21 November 1994¹ , as amended by Directive 2000/61/EC of the European Parliament and of the Council of 10 October 2000² , Commission Directive 2004/111/EC of 9 December 2004³ , Council Directive 95/50/EC of 6 October 1995⁴ Directive 2001/26/EC of the European Parliament and of the Council of 7 May 2001⁵ Commission Directive 2004/112/EC of 13 December 2004⁶ , and Commission Decision 2002/886/EC of 7 November 2002⁷ and Commission Decision 2005/263/EC of 4 March 2005⁸ , hereby make the following regulations:

Citation.

1. These Regulations may be cited as the European Communities (Carriage of Dangerous Goods by Road)(ADR Miscellaneous Provisions) Regulations 2006.

Interpretation.

2.         (1)      In these Regulations -

“ADR” means the European Agreement concerning the international carriage of dangerous goods by road, the Annexes to it and the protocol of signature thereto done at Geneva on 30 September 1957, and the amending protocol thereto adopted at Geneva on 28 October 1993;

“Annexes” means Annexes A and B to the ADR referred to in Annexes A and B to Council Directive No. 94/55/EC of 21 November 1994 as amended;

“associated Regulations” means the Carriage of Dangerous Goods by Road Regulations 2006;

“carriage of dangerous goods by road” means any road transport operation performed by a vehicle wholly or partly on public roads, including the activity of loading and unloading, covered by the Annexes, but does not include transport wholly performed within the perimeter of an enclosed area not open to the public;

“carrier” shall be construed in accordance with Regulation 3;

“competent authority” shall be construed in accordance with Regulation 5;

“competent person” shall be construed in accordance with Regulation 7;

“consignor” shall be construed in accordance with Regulation 4;

“Contracting Party” means a state that is a party to the ADR;

“dangerous goods” means those substances and articles the carriage by road of which is prohibited, or authorised only in certain circumstances, by the Annexes and includes wastes (being any dangerous goods or solution or mixture of dangerous goods for which no direct use is envisaged but which is or are transported for reprocessing, dumping, elimination by incineration or other methods of disposal);

“Directive 94/55/EC” means Council Directive 94/55/EC of 21 November 1994¹ , as amended by Directive 2000/61/EC of the European Parliament and of the Council of 10 October 2000² and as last adapted to technical progress by Commission Directive 2004/111/EC of 9 December 2004³ ;

“Directive 95/50/EC” means Council Directive 95/50/EC of 6 October 1995⁴ , as amended by Directive 2001/26/EC of the European Parliament and of the Council of 7 May 2001⁵ , by Council Directive 2002/886/EC of 7 November 2002 as last adapted to technical progress by Commission Directive 2004/112/EC of 13 December 2004⁶ ;

“first registration” means the first registration of a vehicle by the entry of its particulars-

(a)        in the State, in the register of vehicles established under section 131 of the Finance Act 1992 (No.9 of 1992),

(b)        in a state outside of the State, in a register established under a law that corresponds or substantially corresponds to the provisions of section 131 of the Finance Act 1992 ;

“inspector” shall be construed in accordance with Regulation 6;

“vehicle certificate of approval” means the certificate of approval, in the format laid down in Chapter 9.1.3.5 of the ADR, issued for a vehicle pursuant to Part 6 of the associated Regulations;

“vehicle certificate of approval (national transport only)” means the certificate of approval, issued for a vehicle (for the carriage of the dangerous goods by road only in the State) pursuant to Part 6 (but subject to Part 10 as appropriate) of the associated Regulations.

(2)      Without prejudice to the generality of paragraph (3) and subject to Regulations 3,4 and 5 the definitions in Chapter 1.2.1 of the ADR have the same meaning in these Regulations as they have in the ADR.

(3)       A word or expression that is used in these Regulations and that is also used in the ADR or Directive 95/50/EC has, unless the contrary intention appears, the same meaning in these Regulations as in the ADR or that Directive.

(4)       In these Regulations -

(a)     reference to a Chapter of the ADR means a reference to that Chapter in the ADR, applicable as from 1 January 2005,

(b)     reference to a Part of the ADR means a reference to that Part in the ADR, applicable as from 1 January 2005, and

(c)     reference to Annex A or Annex B means a reference to Annex A or Annex B to the ADR, applicable as from 1 January 2005;

and reference to Annexes to the ADR shall be construed accordingly.

Carrier.

3.         (1)       Notwithstanding Regulation 2 (2) and subject to paragraph (2), in these Regulations “carrier” means the person who carries out the transport operation with or without a transport contract and shall be construed as -

(a)      in the case of carriage in a container or vehicle -

(i)       the person who, having a place of business in the State has the management of the container or the vehicle for the time being, or

(ii)      if no person satisfies the requirements of clause (i), the driver of the vehicle or of the vehicle in which the container is carried (as the case may be), and

(b)      in the case of carriage in a tank -

(i)       the person (other than a tank-container or portable tank operator) who, having a place of business in the State owns the tank,

(ii)      if no person satisfies the requirements of clause (i), the person (other than a tank-container or portable tank operator) who, having a place of business in the State acts as agent for the owner of that tank,

(iii)     if no person satisfies the requirements of either clause (i) or (ii), the person (other than a tank-container or portable tank operator) who, having a place of business in the State, has the management of that tank for the time being, or

(iv)     if no person satisfies the requirements of clause (i), (ii or (iii), the driver of the vehicle on which the tank is carried.

(2)       A person shall not be regarded as the carrier solely because -

(a)      he or she has the management of a tank, container or vehicle during loading or unloading, or

(b)      the tank, container or vehicle is on a premises, which is under his or her control, and

a person to whom a tank, container or vehicle is leased or hired shall be taken to be the owner of that tank, container or vehicle unless the lessor or, as the case may be, the hirer has made an agreement in writing with the person to whom he or she has leased or hired the tank, container or vehicle to the effect that the lessor or hirer (as the case may be) shall assume responsibilities as the owner imposed by or under these Regulations.

Consignor.

4.         (1)       Notwithstanding Regulation 2 (2) and subject to paragraph (2), in these Regulations “consignor” means the person who consigns dangerous goods either on that person's own behalf or for a third party and shall be construed as -

(a)     a person who, having a place of business in the State supplies whether as a principal or agent for another, dangerous goods for carriage by road, or

(b)     if no person satisfies the requirements of paragraph (a), the consignee of those goods in so far as that person has control over the carriage of those dangerous goods in the State.

(2)       If the transport operation is carried out under a contract for carriage “consignor” means the consignor according to the contract for carriage.

Competent Authority.

5          Notwithstanding Regulation 2(2), the following persons are appointed as the competent authorities in the State for the purposes of these Regulations and the functions to be performed by them are set out as follows namely:

(a)     the Minister for Transport, in respect of issue of a vehicle certificate of approval (national transport only) pursuant to Regulation 13 (3);

(b)     the Minister for Justice, Equality and Law Reform, in respect of-

(i)       the approval of the design of, and the requirements to be met in regard to, the containers and compartments used in the carriage of packages of substances and articles of the ADR Class 1, in accordance with Regulation 17 (e (i), and

(ii)      the requirements to be met as regards the design construction, testing, examination, operation and use of the vessels to be used in the carriage of substances of the ADR Classes 3, 5.1 or 8, in accordance with Regulation 17(e)(ii); and

(c)     the Health and Safety Authority, in respect of all other functions conferred on a competent authority by these Regulations.

Inspectors.

6.         (1)       A competent authority may appoint such and so many persons as the authority thinks fit to be inspectors for the purposes of these Regulations and may revoke any such appointment.

(2)       A competent authority shall issue to every inspector appointed by it under paragraph (1) a warrant of appointment and, when exercising a power conferred on an inspector by or under these Regulations, the inspector shall, on being so requested by a person affected, produce the warrant or a copy of it duly authenticated by the competent authority, to that person.

(3)       An inspector may, for the purposes of ascertaining whether these Regulations are being complied with, do any or all of the following:

(a)     carry out a check on any transport equipment for reasons of safety inherent in the carriage of dangerous goods by road,

(b)     at any time enter any premises or place if he or she has reasonable grounds for suspecting that it is used for a purpose connected with the carriage of dangerous goods by road, or that transport equipment used for that purpose is at the premises or place, and inspect the premises or place, the transport equipment and any documents or records kept or used on the premises or place or that transport equipment,

(c)     where he or she has reasonable grounds for suspecting that at any premises or place an offence under these Regulations has been or is being committed, use reasonable force where necessary in order to enter the premises or place, provided he or she is so authorised by a warrant of a judge of the District Court under Regulation 18 or, if it appears to the inspector to be a case of emergency and that the delay in obtaining a warrant would be likely to endanger life, then without being so authorised,

(d)     when exercising a power under this Regulation, be accompanied by a member of the Garda Síochána if the inspector has reasonable cause to apprehend a serious obstruction in the execution of the inspector's duty,

(e)     at any time check transport equipment which is stationary together with its load, if any, and inspect any documents goods, records or recording equipment being carried in or on the vehicle or by any member of the crew, which are kept or used for a purpose connected with the carriage of dangerous goods by road,

(f)      take samples of goods from any premises, place or transport equipment which the inspector has reasonable grounds for suspecting is being used, has been used or is intended to be used for the carriage of dangerous goods by road,

(g)     require any person at the premises, in the place or in the transport equipment to produce to the inspector any document or record (including in the case of information in a non-legible form a copy of an extract from such information in permanent legible form) kept or used for a purpose connected with the carriage of dangerous goods by road which is in the power or control of that person,

(h)     inspect, examine and take copies of or extracts from or take away, if necessary, for the purposes of inspection or examination, any document or record (including in the case of information in a non-legible form a copy of an extract from such information in permanent legible form) kept or used in connection with the carriage of dangerous goods by road and require the person by whom such document or record is kept or who produced the document or record to certify a copy thereof as a true copy,

(i)       investigate any accident involving carriage of dangerous goods by road, and

(j)       undertake, or arrange for the undertaking, of the examination, testing, processing or dismantling of transport equipment as may be necessary.

(4)       For the purpose of exercising his or her powers under paragraph (3), an inspector may detain transport equipment, including any dangerous goods contained therein or thereon, during such time as is required for the exercise of those powers.

(5)       An inspector shall not, other than with the consent of the occupier enter such part of a premises used as a private dwelling unless he or she has obtained a warrant from the District Court under Regulation 18 authorising such entry.

(6)       Where an inspector in the exercise of his or her powers under this Regulation is prevented from entering any premises an application may be made under Regulation 18 for a warrant authorising such entry.

(7)       Where a competent authority is satisfied that an inspector appointed by it has, in good faith duly exercised a power conferred on the inspector pursuant to this Regulation the competent authority shall indemnify the inspector against all actions or claims however arising in respect of the exercise by the inspector of that power.

(8)       A person who obstructs or interferes with an inspector when the inspector is exercising a power under this Regulation, or who fails or refuses to comply with a request or requirement of an inspector under this Regulation, shall be guilty of an offence.

(9)       A person who wilfully gives to an inspector information which he or she knows to be false or misleading in a material respect, or makes any such false or misleading statement reckless as to its truth or otherwise, is guilty of an offence.

(10)     A person guilty of an offence under paragraph (8) or (9) shall be liable on summary conviction to a fine not exceeding €1,900.

Competent person.

7.                     (a)     For the purposes of these Regulations, a person is deemed to be a competent person where, having regard to the task that he or she is required to perform and taking account of the size or hazards (or both of them) of the undertaking or establishment in which he or she undertakes work, the person possesses sufficient training, experience and knowledge appropriate to the nature of the work to be undertaken.

(b)     Account shall be taken, as appropriate, for the purposes of paragraph (a) of the framework of qualifications referred to in the Qualifications (Education and Training) Act 1999 (No. 26 of 1999).

Revocation.

8          The European Communities (Safety Advisers for the Transport of Dangerous Goods by Road and Rail) Regulations 2001 ( S.I. No. 6 of 2001 ) are revoked in so far as they relate to the transport of dangerous goods by road.

Requirement for road checks.

9.         (1)       The competent authority shall, for the purposes of Directive 95/50/EC -

(a)      fulfil the checks requirements in paragraphs 1 and 2 of Article 3 of that Directive,

(b)      carry out checks in accordance with paragraphs 1 to 5 of Article 4 of that Directive,

(c)      co-operate with competent authorities in other Member States of the European Communities in fulfilling the requirements of paragraph 2 of Article 7 and Article 8 of that Directive, and

(d)      supply such information to the Commission of the European Communities as is required by paragraph 1 of Article 9 of that Directive.

(2)       Where an inspector carries out a check for the purposes of subparagraph (1)(a), a certificate containing the particulars set out in Schedule 1, showing the result of the check as required by paragraph 1 of Article 4 of Directive 95/50/EC shall be drawn up by the inspector and given to the driver of the vehicle.

Defence forces exemption and certificate of exemption.

10.       These Regulations do not apply to vehicles carrying dangerous goods belonging to, or under the control of, the Defence Forces or the armed forces of a country which is a contracting party to the ADR.

General exemption relating to carriage of dangerous goods by road in the State and certificate of exemption.

11.       (1)        A competent authority may, subject to any law of the European Communities in respect of the carriage of dangerous goods by road, and following consultation with the Minister, by certificate in writing exempt, in respect of the carriage of dangerous goods by road in the State, a participant from any requirement imposed upon him or her by the associated Regulations and any such exemption may be granted subject to conditions and for such a period of time as the competent authority sees fit to impose and may be revoked at any time.

(2)       A participant availing of an exemption under paragraph (1) shall ensure that a copy of the certificate of exemption accompanies the load of dangerous goods at all times, while it is being carried by road.

Application of exemptions in Regulations 13 to 17.

12.       The exemptions set out in Regulations 13 to 17 apply only to the carriage of dangerous goods by road in the State.

Existing vehicles.

13.       (1)       Notwithstanding Parts 2 and 3 of the associated Regulations, and by derogation from Part 9 of the ADR relating to anti-lock braking systems and endurance braking, vehicles not fitted with anti-lock brakes and endurance braking and first registered before 1 April 2002 shall be taken to comply with Part 6 of the associated Regulations as respects the requirements for anti-lock and endurance braking systems in Chapter 9.2.3.1 of the ADR.

(2)       Notwithstanding Parts 2 and 3 of the associated Regulations, and by derogation from Part 9 of the ADR, vehicles first registered before 1 April 2002 which do not comply with Part 9 and in particular Chapter 9.3 of the ADR may be used to carry explosives of ADR Class 1 Division 1.1 in quantities not exceeding 5000 kg, provided that -

(a)     a quick action cut-off is fitted to the fuel feed pipe in an accessible position,

(b)     the cab is separated from the body of the vehicle by a clear space of at least 152 mm and the whole of the exhaust pipe is protected from the body by a fire resisting screen carried down to within 304 mm of the ground,

(c)     the body of the vehicle, including the floor is completely covered externally with sheet metal and lined internally with wood so treated as to be rendered non flammable or with such other material as may be approved in writing by an inspector,

(d)     the floorboards and side doors of the cab, if of wood, are so treated as to be rendered non flammable, and

(e)     there is no opening in the body of the vehicle except the door which shall fit closely and shall be at the back unless another position is approved in writing by an inspector.

(3)       Notwithstanding Parts 2 and 3 of the associated Regulations, and by derogation from Part 9 of the ADR regarding the issue of a vehicle certificate of approval, in the case of -

(a)     vehicles referred to in paragraphs (1) and (2), and

(b)     tank-vehicles meeting the ADR requirements for the base vehicle but fitted with a tank not meeting the requirements of the ADR,

on the successful completion of the inspection under Part 6 of the associated Regulations and subject to paragraphs (1) or (2), the competent authority may issue a vehicle certificate of approval (national transport only) for that vehicle in the form contained in Schedule 2 of the associated Regulations.

(4)       (a)     The carrier and the driver of a vehicle referred to in paragraph (3) shall ensure that the vehicle certificate of approval (national transport only) is carried in the cab of the vehicle whenever the vehicle is being used for the transport of dangerous goods.

(b)     Notwithstanding -

(i)        subparagraph (a), in the case of a vehicle referred to in this Regulation, where the vehicle consists of a drawing vehicle coupled to a trailer or a semi-trailer and is being used for the carriage of dangerous goods, the vehicle certificate of approval (national transport only), or

(ii)        Parts 2 and 3 of the associated Regulations, and by derogation from Chapter 8.1.2.2(a) of the ADR, where the vehicle consists of a drawing vehicle coupled to a trailer or a semi-trailer and is being used for the carriage of dangerous goods within the State only, the vehicle certificate of approval,

for the trailer or semi-trailer component need not be carried on the transport unit but must be produced, on request, at an agreed location to an inspector or a member of An Garda Siochana, as appropriate, within 10 days of such request.

(5)       (a)     A carrier or a driver who fails to comply with subparagraph (4)(a) is guilty of an offence and is liable on summary conviction to a fine not exceeding €600.

(b)     A carrier who fails to comply with a request under subparagraph (4)(b) is guilty of an offence and is liable on summary conviction to a fine not exceeding €600.

Tanks etc. constructed before 1 July 2003.

14.       Notwithstanding Parts 2 and 3 of the associated Regulations, a fixed tank or a demountable tank or a tank-container and their respective fittings, that is not fully in compliance with Chapter 6.8, 6.9 or 6.10 of the ADR and that was constructed before 1 July 2003, shall be taken to comply with the associated Regulations and with Regulations 7 to 9 of the Air Pollution Act 1987 (Petroleum Vapour Emissions Regulations 1997 ( S.I. No. 375 of 1997 ) where -

(a)     all practicable steps are taken to ensure that the fixed tank demountable tank or tank-container, as the case may be, and its fittings meet the requirements specified in Schedule 2.

(b)     the fixed tank, demountable tank or tank-container, as the case may be, is fitted with a corrosion-resistant metal plate or plates permanently attached to the tank in a place readily accessible for inspection, and

(c)     the following particulars, regarding the fixed tank, demountable tank or tank container, are marked on the plate or plates referred to in paragraph (b), by stamping into the metal or other similar method:

(i)         its serial number,

(ii)        its water capacity in litres,

(iii)       its maximum safe working pressure,

(iv)       the month and year of its most recent thorough examination,

(v)        the month and year of its most recent periodic test, if appropriate,

(vi)       the month and year of its most recent leakproofness test,

(vii)      its operating temperature range, if appropriate, and

(viii)      the identification mark of the competent person who carried out the most recent thorough examination periodic inspection or leakproofness test, as appropriate.

Gas receptacles constructed before 1 July 2003.

15.       Notwithstanding Parts 2 and 3 of the associated Regulations, a receptacle used for the carriage of gases of the ADR Class 2 and its fittings, that is not fully in compliance with Chapter 6.2 of the ADR and that was constructed before 1 July 2003 is taken to comply with the associated Regulations where -

(a)     all practicable steps are taken to ensure that the receptacle and its fittings are -

(i)       properly designed, of adequate strength, good construction and free from obvious defect,

(ii)      constructed of materials that are not chemically incompatible with or liable to react dangerously with the dangerous goods being carried,

(iii)     suitable for the purpose for which it is being used,

(iv)     designed, constructed and maintained so as to prevent any of the contents escaping except in the interests of safety, where the contents may be released using a suitable safety device, and

(v)     thoroughly examined externally and internally by a competent person at the intervals specified in the ADR and after any major repairs which may affect the integrity or safety of the receptacle, and

(b)     the receptacle has the following particulars stamped either into the metal on a reinforced part of the receptacle or on a ring or disc immovably affixed to the receptacle -

(i)       the name of the owner,

(ii)      its serial number,

(iii)     its year of manufacture,

(iv)     its water capacity in litres,

(v)     its test pressure,

(vi)     (I)       the year and, subject to clause (II), the month of its last thorough examination,

(II)     where a receptacle is used to carry gases of the ADR Class 2 for which the interval between periodic inspections is 10 years or more the month of the last thorough examination need not be indicated,

(vii)    (I)       the tare weight of the receptacle without fittings and accessories, or

(II)     in the case where the receptacle is an LPG (propane, butane or mixtures of propane and butane of the ADR Class 2, with UN numbers UN 1978, UN 1011 and UN1965 respectively cylinder the tare weight inclusive of fittings and accessories,

and

(viii)    the identification mark of the competent person who carried out the test or examination.

Exemption relating to private premises.

16.       Notwithstanding Parts 2 and 3 of the associated Regulations, those Regulations do not apply where a vehicle is being used to transfer dangerous goods -

(a)     between private premises and another vehicle situated in the immediate vicinity of those premises, or

(b)     between one part of a private premises and another part of the premises situated in the immediate vicinity of that first mentioned part, where both parts are occupied by the same person, notwithstanding that those parts may be separated by a public road,

provided that the transfer of the dangerous goods is carried out by means of the most direct and shortest route between a private premises and a vehicle or the two parts of a private premises, as appropriate.

Other miscellaneous exemptions.

17.       The following exemptions (subject to the conditions therein referred to) apply to the provisions of Parts 2 and 3 of the associated Regulations namely:

(a)      where kerosene bearing UN number 1223, diesel fuel bearing UN number 1202 or liquefied petroleum gas bearing UN number 1965 is being carried for delivery to the end user-

(i)         the transport document which, pursuant to Chapter 5.4 of the ADR, is required at the start of the transport operation is not required to contain the name and address of a consignee, and

(ii)        the transport document, referred to in subparagraph (i) is not required to comply with Chapter 5.4.1.1.1(h) of the ADR;

(b)      In the case of the carriage of empty uncleaned tanks, the transport document for the last load shall be sufficient;

(c)     In the case of a storage tank used at a fixed location, the provisions of Chapters 6.7 and 6.8 and the relevant provisions of 3.2 of the ADR do not apply to its carriage when it is empty and uncleaned, for the purpose of cleaning, repair or scrapping provided that-

(i)         the tank is not used for the carriage of dangerous goods by road,

(ii)        as much of the pipe work which was connected to the tank as it was reasonably practicable to remove from it has been removed,

(iii)       a suitable pressure relief valve, which shall remain operational during the carriage, is fitted to the tank,

(iv)       with the exception of the pressure relief valve required under subparagraph (c), all of the openings in the tank and in any pipe work (still attached to the tank) have been sealed to prevent the escape of any dangerous goods remaining in the tank;

(d)      notwithstanding the provisions of Chapter 7.5.11 of the ADR the loading and unloading of dangerous goods in a public place to which special provision CV1 of that Chapter applies, is permitted without special permission from a competent authority;

(e)      packages containing articles of Compatibility Group B of the ADR Class 1 and packages containing substances and articles of Compatibility Group D of the ADR Class 1 may be carried on the same vehicle with dangerous goods of the ADR Classes 3, 5.1 or 8, where -

(i)         the said packages of the ADR Class 1 are carried in separate containers or compartments of a design approved and in compliance with the conditions required by the relevant competent authority, and

(ii)        the said substances of the ADR classes, 3, 5.1 or 8 are carried in vessels meeting the requirements of the competent authority as regards their -

(I)       design, construction, testing, examination

(II)     operation and use;

(f)      flexible hose reels (including fixed pipelines associated with them) attached to tank vehicles engaged in the retail distribution of petroleum products with UN numbers 1011 1202, 1223, 1995 or 1978 are not required to be empty during carriage by road where adequate measures are taken by the carrier to prevent any loss of contents;

(g)     a transport document as referred to in Chapter 5.4 of the ADR is not required for the carriage of pesticides of ADR Class 3, with the Classification Code FT2, and pesticides of ADR Class 6 with the Classification Code T6, where the quantity of the dangerous goods being carried does not exceed the quantities set out in Chapter 1.1.3.6 of the ADR.

(h)     Subject to paragraph (i), the carriage of marine distress pyrotechnical articles of ADR Class 1, with UN numbers 0092 0093, 0403 or 0404 to the nearest military barracks is exempt from -

(i)       the requirement for a transport document in accordance with Chapter 8.1.2.1(a) of the ADR,

(ii)      the packaging requirements of Chapters 4.1 and 6.1 of the ADR, and

(iii)     the package marking and labelling requirements of Chapter 5.2 of the ADR;

(i)       Paragraph (h) applies to the article referred to in that paragraph pursuant to chapters 4.1.1.1 and 4.1.1.2 of the ADR where -

(i)       the carriage of the articles is for their disposal following the expiry of their shelf life,

(ii)      they are packaged by one of the methods listed in the packing instruction P135 of Chapter 4.1.4 of the ADR,

(iii)     their packagings are -

(I)      of good quality,

(II)     strong enough to withstand the shocks and loadings normally encountered during carriage,

(III)   constructed and closed so as to prevent loss of contents during carriage, and

(IV)    not affected or significantly weakened by the pyrotechnical articles,

(iv)     they are not packed together with any other article or substance,

(v)     each package is clearly marked with the following inscription, namely -

“Time Expired Pyrotechnics”,

(vi)     the carriage is in compliance with -

(I)      chapter 1.1.3.6 of the ADR,

(II)     the exemptions related to quantities carried per transport unit, and

(III)   the conditions to which the exemptions are subject pursuant to paragraph (9).

(vii)    the load is accompanied by a transport document containing -

(I)      the name and address of the consignor,

(II)     the name and address of the military barracks to which the load is being consigned,

(III)   a description of the articles being consigned including their UN number, name and classification code,

(IV)    the number of packages and total mass of the load of them, and

(V)     the following inscriptions:

(A)     “Time Expired Pyrotechnics”, and

(B)     “Load not exceeding the exemption limits prescribed in Chapter 1.1.3.6 ofthe ADR”,

(viii)    their carriage is to the nearest military barracks,

and

(ix)     a complete itemised list of the articles is provided to the military barracks at least two days prior to the delivery of the articles;

(k)     in the case of the carriage in bulk of ammonium nitrate based fertiliser with UN number 2067, from a port where it is being unloaded from a ship, where the carriage involves multiple loads in the same vehicle of that fertiliser only on the same or consecutive days -

(i)       the transport document, required by Chapter 8.1.2.1(a of the ADR to be provided in respect of the first load shall be sufficient for subsequent loads in respect of the same vehicle on the same or subsequent consecutive days, and

(ii)      the special provision CV24, of Chapter 7.5.11 of the ADR, shall not apply, provided that it is complied with before the first load and after the last load in respect of the same vehicle;

(l)       the requirements of Chapters 5.3 and 5.4 and Parts 7, 8 and 9 and the provisions of Chapter 3.2 of the ADR that relate to carriage of gases to be used as dispensing agents for beverages do not apply to the carriage of gases of ADR Class 2 in cylinders, provided that as respects beverages for which the gases being carried are to be used as dispensing agents where the gases and beverages are being carried in the same vehicle -

(II)     they are so carried on the same vehicle as the beverages,

(III)   the gases are dispensing agents for the beverages, and

(IV)    the beverages are not classified as dangerous according to the ADR;

and

(m)     the provisions of Chapters 4.1, 6.2 and Columns (8), (9a) and (9b) of Chapter 3.2 of the ADR do not apply to the carriage of gases of ADR Class 2 in cylinders or pressure drums in the case of a multimodal carriage, that includes carriage by sea, of the gases, provided that -

(i)       consignors comply with the provisions of Chapters 4.1 and 6.2 and the relevant provisions of Chapter 3.2 of the IMDG Code,

(ii)      the carriage within the State consists of a single journey and is completed within a single day

(iii)     the cylinders or pressure drums are not refilled in the State,

(iv)     the empty cylinders or pressure drums, whether uncleaned or cleaned, are returned to the country of origin, from where they originated, and

(v)     small quantities are carried per load.

Search warrants.

18.       If a judge of the District Court is satisfied on the sworn information of an inspector that there are reasonable grounds for suspecting that -

(a)     a premises is used for a purpose connected with the carriage of dangerous goods by road,

(b)     transport equipment used for that purpose is at the premises,

(c)     there is information or material relating to the carriage of dangerous goods by road required by an inspector for examination held in any premises or part of any premises, or

(d)     an offence under these Regulations has been or is being committed therein,

the judge may issue a warrant authorising an inspector, accompanied by other inspectors or members of the Garda Síochána, at any time or times within one month from the date of issue of the warrant, on production if so required of the warrant, to enter that premises, if need be by reasonable force, and exercise all or any of the powers conferred on an inspector under Regulation 6.

Schedule 1

Checklist Certificate

1.  Place of check......................................................................

2.  Date..................................................... 3. Time............................

Documents on board

Transport operation

Equipment on board

40.  Remarks .............................................................................................................................................................................................................................................................................................................................................................................................................

41. Authority/officer having carried out the inspection .....................................

Schedule 2

Specific requirements relating to fixed tank, demountable tank or tank-container under Regulation 7

Part 1

Miscellaneous Provisions

General provisions

1.         All practicable steps must be taken to ensure that the fixed tank, demountable tank or tank-container and its fittings -

(a)      are properly designed, of adequate strength, good construction and free from patent defect,

(b)      are constructed of materials that are not chemically incompatible with or liable to react dangerously with the dangerous goods being carried,

(c)      are suitable for the purpose for which it is being used,

(d)      are designed, constructed and maintained so as to prevent any of the contents escaping except that this requirement shall not prevent the fitting of a suitable safety device,

(e)      comply, as appropriate, with -

(i)         Chapter 6.8.2.1.28 of the ADR, concerning protection of fittings mounted on the upper part of the tank,

(ii)        Chapters 6.8.2.2, 6.8.3.2 and 6.8.4(b) of the ADR concerning items of equipment (shells made of metallic materials),

(iii)       Chapter 6.9.3 of the ADR, concerning items of equipment (shells made of fibre-reinforced plastics), and

(iv)       Chapter 6.10.3 of the ADR, concerning items of equipment (vacuum-operated waste tanks).

Sections 2, 3, 4 and 6 of the LPG ITA Code of Practice 2 of January 1974.

2.         A fixed tank or tank-container, complying with Sections 2, 3, 4 and 6 of the LPG ITA Code of Practice 2 of January 1974, issued by the United Kingdom Liquefied Petroleum Gas Industry Technical Association, and used for the carriage of propane, butane or mixtures of propane and butane of the ADR Class 2 with the UN Numbers UN 1978, UN 1011 and UN 1965, is deemed to comply with paragraph 1 (a), (b), (c) and (e) where the tank has been designed, constructed and initially tested in accordance with -

(a)      one of the following standards of the ‘British Standards Institution’ -

(i)       BS 1500: 1958, entitled ‘Fusion Welded Pressure Vessels for General Purpose’,

(ii)      BS 1515: 1965, entitled ‘Fusion Welded Pressure Vessels for Use in the Chemical, Petroleum and Allied Industries’, or

(iii)     BS 5500: 1976, entitled ‘Specification for Unfired Fusion Welded Pressure Vessels’, or

(b)     the ‘ASME Boiler and Pressure Vessel Code: 1962: Section VIII, Pressure Vessels’ of the ‘American Society of Mechanical Engineers’.

Examinations, inspections and tests.

3.         All practicable steps must be taken to ensure that the fixed tank, demountable tank or tank-container and its fittings -

(a)      in the case of fixed tanks used for the carriage of substances with the UN Numbers UN 1202, UN 1203 or UN 1223, is thoroughly examined both internally and externally by a competent person every 6 years and after any major repairs which affect the integrity or safety of the said tank, or

(b)      subject to subparagraph (a), undergoes a periodic inspection by a competent person, in the manner (subject to any conditions or requirements of the competent person) set out in and at the intervals specified, as appropriate, in Chapters 6.8.2.4, 6.8.3.4 6.8.4(d), 6.9.5 and 6.10.4 of the ADR and after any major repairs which affect the integrity or safety of the said tank or tank container,

(c)      in the case of fixed tanks used for the carriage of substances with the UN Numbers UN 1202, UN 1203 or UN 1223, is subjected to a leakproofness test by a competent person every 3 years in the manner (subject to any conditions or requirements of the competent person) set out in Chapter 6.8.2.4 of the ADR, or

(d)      subject to subparagraph (c), is subjected to a leakproofness test by a competent person, in the manner (subject to any conditions or requirements of the competent person) set out in and at the intervals specified, as appropriate, in Chapters 6.8.2.4, 6.8.3.4 6.8.4(d), 6.9.5 and 6.10.4 of the ADR.

Certificates of examinations, inspections and tests.

4.         A certificate of the results of every examination, inspection or test referred to below must be kept available and produced to an inspector on request and to an authorised examiner when required under Part 6 of these Regulations, in respect of a -

(a)      thorough examination carried out in accordance with paragraph 3(a) and containing the prescribed particulars as set out in Part 2 of this Schedule and signed by the person making the examination,

(b)      periodic inspection carried out in accordance with paragraph 3(b) and containing the prescribed particulars as set out in Part 3 of this Schedule and signed by the person carrying out the periodic inspection, and

(c)      leakproofness test carried out in accordance with paragraph 3 (c or (d) and containing the prescribed particulars set out in Part 4 of this Schedule and signed by the person carrying out the leakproofness test.

Part 2

Particulars to be included in Certificate of Thorough Examination of Tank

1.         Name of owner

2.         Address of owner

3.         Serial number

4.         Vehicle registration number or where the certificate is required in respect of a trailer or semi-trailer the chassis number

5.         Year of manufacturer if known

6.         Name of manufacturer (if known)

7.         Water capacity in litres

8.         Results of examinations carried out

9.         Any repairs or modifications required before being put back into service

10.       Other observations

11.       Dangerous substances for which the tank is suitable

I/We certify that on (date) I/We -

(a)      thoroughly examined the tank described above externally and internally

(b)      carried out a leakproofness test^* -

(i)       of the tank, after assembly of equipment, and

(ii)      of all items of equipment of the tank

and I/We am/are satisfied that the tank and its equipment are operating satisfactorily.

Signed________________________Date______________

Company________________________

Address________________________

Part 3

Particulars to be included in Certificate of Periodic Inspection of Tank

1.         Name of owner

2.         Address of owner

3.         Serial number

4.         Vehicle registration number or where the certificate is required in respect of a trailer or semi-trailer the chassis number

5.         Year of manufacturer if known

6.         Name of manufacturer (if known)

7.         Tare weight including equipment and fittings

8.         Maximum gross weight in kilograms

9.         Capacity in litres (water)

10.       Design temperature (if above +50°C or below -20°C)

11.       Maximum working pressure of the tank

12.       Description of pressure relief devices if fitted

13.       Operating pressure of relief devices

14.       Results of examinations carried out

15.       Any repairs or modifications required before being put back into service

16.       Other observations

17.       Dangerous substances for which the tank is suitable

I/We certify that on (date) I/We -

(a)      thoroughly examined the tank described above externally and internally,

(b)      subjected the tank to a pressure test at a pressure of ^* ,

(c)      carried out a leakproofness test^** -

(i)       of the tank, after assembly of equipment, and

(ii)      of all items of equipment of the tank,

(d)     examined the condition of the lining of the tank^*

and I/We am/are satisfied that the tank, its equipment, and the lining of the tank^* , are operating satisfactorily.

Signed_____________________Date_____________________

Company _____________________

Address _____________________

_____________________

_____________________

Part 4

Particulars to be included in Certificate of Leakproofness of Tank

1.         Name of owner

2.         Address of owner

3.         Serial number

4.         Vehicle registration number or where the certificate is required in respect of a trailer or tank semi-trailer the chassis number

5.         Test pressure applied

6.         Results of leakproofness test

7.         Other observations

I/We certify that on (date) I/We -

(a)     carried out a leakproofness test^* of the tank described above together with all items of equipment, and

(b)     tested all items of equipment of the tank for satisfactory operation, and I/We am/are satisfied that the tank and its equipment are operating satisfactorily.

Signed_____________________ Date_____________________

Company_____________________

Address _____________________

EXPLANATORY NOTE

(This note is not part of the Instrument and does not purport to be a legal interpretation.)

These Regulations apply to the carriage, in tanks, in bulk and in packages, of dangerous goods by road. They complement the provisions of the “associated Regulations”, namely, the Carriage of Dangerous Goods by Road Regulations 2006 made under the Carriage of Dangerous Goods by Road Act 1998 .

The Regulations contain provisions on an EC harmonised approach to the road checks aspect of their enforcement. They also implement certain exemptions which are in addition to those contained in the Annexes A and B to the “European Agreement Concerning the International Carriage of Dangerous Goods by Road” (ADR) 2005.

The Regulations transpose or retranspose relevant elements of -

•    Council Directive 94/55/EC of 21 November 1994, on the transport of dangerous goods by road (as amended by Commission Decision 2002/886/EC of 7 November 2002 regarding time-limits in relation to pressure drums cylinder racks and tanks and Commission Decision 2005/263/EC of 4 March 2005 regarding certain derogations in relation to national transport), and

•    Council Directive 95/50/EC of 6 October 1995, on uniform procedures for checks on the transport of dangerous goods by road (as amended by Directive 2001/26/EC of the European Parliament and of the Council of 7 May 2001 amending Directive 95/50/EC and Commission Directive 2004/112/EC of 31 December 2004 which replaces the Annexes to Directive 95/50/EC);

which were not otherwise transposed through the Carriage of Dangerous Goods by Road Regulations 2006.

¹ O.J. No. L 319, 12.12.1994, p.7

² O.J. No. L 279, 1.11.2000, p.40

³ O.J. No. L 365, 10.12.2004, p.25

⁴ O.J. No. L 249, 17.10.1995, p.35

⁵ O.J. No. L 168, 23.6.2001, p. 23

⁶ O.J No. L 367, 14.12.2004, p. 23

⁷ O.J. No. L 308, 9.11.2002, p.45

⁸ O.J. No. L 85, 2.4.2005, p.58

¹ O.J. No. L 319, 12.12.1994, p.7

² O.J. No. L 279, 1.11.2000, p.40

³ O.J. No. L 365, 10.12.2004, p.25

⁴ O.J. No. L 249, 17.10.1995, p.35

⁵ O.J. No. L 168, 23.6.2001, p. 23

⁶ O.J No. L 367, 14.12.2004, p. 23

(¹) To be filled only if relevant for an infringement.

(²) To be stated under “remarks” for groupage transport operations.

(¹) To be filled only if relevant for an infringement.

(²) To be stated under “remarks” for groupage transport operations.

(³) Check of visible violations.

(³) Check of visible violations.

(²) To be stated under “remarks” for groupage transport operations.

(³) Check of visible violations.

(²) To be stated under “remarks” for groupage transport operations.

^* The leakproofness test shall be carried out separately on each compartment of a compartmented shell.

^* Delete if not applicable

^** The leakproofness test shall be carried out separately on each compartment of a compartmented shell.

^* Delete if not applicable

^* Delete if not applicable

^* The leakproofness test shall be carried out separately on each compartment of a compartmented shell.